Dealer repair description:"Replace mechatronic assembly". The contact did not notice if any warning indicators were illuminated. My air conditioning blows warm air when I am sitting at a idle, so I just ordered a new air compressor for it - I haven't got that from the seller yet so I can't have it installed to see if that remedies that problem. Transmission problems Description: The engine speed may vary from 50-100 rpm on vehicles equipped with a continuously variable transmission (CVT) requiring reprogramming the powertrain control module. wrench and check engine light on little or no throttle response. Hope this helps and thanks for using 2CarPros. CVT Problems on a 2005 Ford 500 - Car Talk Community The codes he got when he did a reading were P0420, P0304, & P0300. Replaced F2 fuse for interior lights and power windows but fuse blows instantly when installed is there a way to find out what is causing this by hooking it up to a computer? Had the computer flashed for updates while the trans was serviced , no change - $85 hook up & $65 update . They seem to be sensor codes, but I understand the sensors are within the unit. The transmission dipstick will typically be in the engine bay or on top or even the side of your Five Hundred transmission. The vehicle was coasted down an incline and then the transmission began to operate normally. Hopefully, you are clear on the Ford 500 CVT Transmission Recall. 151 kilowatts 3.0L V6 6-speed automatic FWD. Check Engine Light 2005 Ford Five Hundred Engine not specified 91000 mi US $2000 Car hesitates when downshifting at 25 and 35 mph once it is heated up (212F or higher per TSB). It has had mixed reviews. Turn signal/hazards on the right side flashes then stops. If you own a 2005-2006 Ford Five Hundred or Mercury Montego with a CVT, be sure to schedule an appointment with your local Ford dealer to get the software update. Starting in early 2000's, many car makers including Ford started installing fly by wire electronic throttle bodies. Wrench light came on. NO serviceable filter. I had approximately 1/4 tank of gas in my car when the fuel cap warning light came on. The contact stated that while accelerating from a traffic stop, the transmission failed to operate with a sudden increase of engine rpms. 2006 Ford Five Hundred 100,000 mi, Visitor. radiator 2005 Ford Five Hundred Recalls & Safety Notices - Kelley Blue Book .. Ford will notify affected owners and dealers will update the powertrain control module software, free of charge. Will repair myself. The car would shudder when accelerating or slowing down. Body shop says I should replace the whole damn thing for.. The next day the warning lig.. We don't sell/share your email. SOLVED: Why is my Ford 500 wrench light - Fixya Our system selects the most applicable video for your car based, in part, on these characteristics. It was running totally fine before this, but yesterday I was driving down the highway and noticed that the revs were acting up a little bit. The failure mileage was 145,753. If trans is slipping, you typically have rpms or engine revs up, but car doesn't pull off or it doesn't increase in speed along with rpms and rpms rev higher than normal while accelerating. Has anyone had this problem or is it a characteristic of the car,or. How they handle this issue will definitely affect my decision re whether or not to pursue. These transmissions arent really rebuildable and a new one will run you around 6 grand before labor. Ford throttle body relearn procedure - Ricks Free Auto Repair Advice I had transmission problems and the Ford dealer rebuilt the transmission under warranty. Five Hundred / Montego Reviews. The CVT also works with the engine control system, including the electronic throttle, to find the best compromise of torque, fuel efficiency and emissions. He said it was a throttle control sensor or check sensor, or something along those lines. @media(max-widt.. New Transmission required. Est. No previous transmission issues, and I take very good care of the car, with recent dealer maintenance. Transmission(?) Problems with 2005 Ford Five Hundred : r/Cartalk - reddit I had other problems with the transmission within the first year (nothing as serious as this) and Im wondering if a new replacement will have those same issues. Is ther.. 2005 Ford 500 132000 miles Press question mark to learn the rest of the keyboard shortcuts. 2006 Ford Five-Hundred Common Problems, Issues, Recalls, and GM is aware of one crash and two injuries that are potentially related to the defect. Ford Five Hundred - Wikipedia If that doesn't fix it I might look at the plugs and wires . . Over the past 10 years, Hans has been focused on building CarCareKiosk, which is visited by millions of drivers each month. @media(max-width: 960px) { .adt { display: none;padding:0; } } It feels as if the vehicle can't decide what gear it wants upon acceleration, it bucks back and forth sometimes trying to choose a gear. However, I would be remiss if I did not mention that when I checked it, the car was off (it was warm, but off) and the surface may not have been entirely level (it's really difficult to find a nice level place where I live and I have not been comfortable driving it much). The time needed for your particular repair may be different. It had a bad jerking problem when I sped up to fast or slowed down fast. Been one year and have not fixed. However, the CVT used in the Ford Five Hundred and Mercury Montego was prone to failure, with the transmission slipping or jerking without warning. Open the Hood - How to pop the hood and prop it open, 3. all problems of the 2007 Ford Five Hundred A reman by previous owner was 65000 miles on an extended warrant. The passenger side half shaft was replaced under warranty. So far it's a one-time problem. 2005 Ford Five Hundred Throttle Body Malfunction I then contacted the parent company FORD, asking who I should take my vehicle to for diagnosis without the idiot codes. Ford service states that the system does not show a code and they do not know what to do abou.. Dented bumper on 2005 ford five SE going about 5 miles per hour while backing up. The vehicle was taken to an independent mechanic for diagnostic testing. The wrench symbol light is a warning light for the electronic throttle control system . AutoFair Ford in Haverhill, MA was unable to diagnose the issue because it was not "throwing any codes". Ford Motor company issued a recall to have my vehicle type brought into the deal to hae he Throttle Bottle cleaned. FORD FIVE HUNDRED OWNER'S MANUAL Pdf Download | ManualsLib 2005 Ford Five Hundred "AWD Limited" with about 135k miles and the CVT trans. The 2005-2007 Ford Five Hundred with automatic climate control may have a problem with frequent fan speed changes when using the heater or air conditioner. I just purchased an 2005 Five Hundred with 5000 miles on it. Source: www.familyautoofgreenville.com. TrueDelta | Ford Five Hundred transmission Problems The driving position, which . A mechanic determined that the transmission failed. Major repairs are usually more time-consuming and may require the help of a professional. It turned off again. Normally, the fan speed changes only to maintain a selected temperature, but when the fan speed changes frequently and needlessly, there is an issue with the fan speed control unit. After he unplugged it , the car had no issues . Here is the information you requested. car stalls, doesn't seem like it's getting any gas. The consumer went to her local dealer and a diagnostic's test revealed a problem with the PCV valve. Ford Five Hundred Questions - Throttle body or transmission? - CarGurus Occasional hesitation or clunk, as if transmission slipping. . Talked with my dealer today, they're going to look at it Friday. 2005 - 2007 Ford Five Hundred Throttle Body Problems - YouTube The resistor is normally found behind the glove box, next to the blower motor. Replace Transmission Fluid Cap/Dipstick - Put the dipstick / cap back in place, 7. Free shipping on . 2005 Ford Five Hundred "Check Transmission" (CVT) to illuminate and could have limited to no throttle response. Recall List for the 2005 Ford Five Hundred Official recalls have been issued for the 2005 Ford Five Hundred by the NHTSA. Vehicle behaved as if stuck in "low gear" (CVT) "check trans" displayed on info screen after restart. I suppose I will have an transmission failure soon to come. The transmission was replaced successfully. Picked up and did not notice any difference, still hard shifting. 2005-2007 FORD FIVE HUNDRED TRANSMISSION VALVE BODY WIRING HARNESS OEM 269232 (Fits: Ford Five . Open the Hood - How to pop the hood and prop it open. Changed the trans fluid & filter , no change - $255 charge . They have 3 of them and if they become plugged your performance will suffer greatly . Ford Five Hundred 2005 Ford 500 Tune-up & Catalytic Converter Ford Five Hundred Door Will Not Latch Closed, Bounces Back, Ford Five Hundred 2005 Ford 500 Conflicting Diagnosis Of Problem, Ford Five Hundred 2005 Ford 500 Fuel Cap Warning Light, Ford Five Hundred 2005 Ford 500 Headlight Wiring Harness, Ford Five Hundred 2005 Ford 500 Power Steering, Ford Five Hundred 2005 Ford 500 Power Steering Noise, Ford Five Hundred 2005 Ford 500 Power Sterring Pump. I agree that they should give you a new transmission, but corporations do not always make decisions that are the best in the long run. 2005 Ford Five Hundred Transmission Problems Unsubscribe any time. Drive by wire ! In some instances, the failure has been attributed to the sealed-for-life nature of the transmission, as the This is not the first time GM has had to recall vehicles due to airbag issues. Of course, I was delighted to have a new engine. The engine in your 2005 Ford Five Hundred should be running when you perform a transmission fluid level check, otherwise it will be inaccurate. If it is, you should take it to a Ford dealer to have the CVT replaced. I made a phone call and limped to a guys house who was a Ford tech and had a computer. On July 23, General Motors (GM) announced a recall of over three million vehicles due to a software defect that could cause airbags to deploy unexpectedly. PS fluid is at operating level to m.. Everything is quiet and normal when the car is cool, but after it heats up there is a loud whining noise whenever I turn the steering wheel. Remanufactured: See availability. I don't know a lot about cars, but I do know that this one has an electronic throttle. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance. The recall is expected to begin on October 22, 2018. I called the Ford care line to report it, but they claim they are unaware of any issues. Looking for installation procedure. consumer writes in regards to hard shifting and two instrument panel lights illuminating. See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. Park the vehicle directly in front of a wall or screen on a level surface, approximately 25 feet (7.6 meters) away. the consumer went to her local dealer and a diagnostic's test revealed a problem with the pcv valve. Tons of room inside and the trunk is huge. The approximate failure mileage was 100,000. 2005 ford 500 132k miles In the meantime, pay close attention to your vehicles warning lights and check the transmission fluid level regularly. After reading all the complaints and issues, why hasn't something been done? @media(max-width: 960px) { .adt { display: none;padding:0; } } Ive had it in the shop twice previously for repairs on the CVT. 2007 Ford Five-Hundred Common Problems, Issues, Recalls, and I proceded to fill the tank with gas and made sure the gas cap was on correctly. I'll keep that code in mind when we look at it today, thanks! $22,840 to $26,640 Price range The price range shown is the range of price from low to high of all matching vehicles listed on CarGurus right now. 2005. *tgw the consumer also stated the rpm's would race at times. Privacy Policy | Terms and Conditions | Copyright Policy. It's the right colour and it seems to be within normal range. 2005 Ford Five Hundred for Sale (with Photos) - CARFAX A cylinder head had a crack and in stripping down the engine, the service manager reported that a cylinder wall was scored and the entire engine would be replaced (this was also under warranty). Sorry man, new car time. Informed dealer of TSB for problem. Binding of the shifter slider can make the transmission shifter difficult to move. The dealership makes more money if their own mechanics get paid by the flat-rate hour to repair it, PS - so far the vote is to push for a replacement. Did NOT solve problem. Clear DTCs. The vehicle was not repaired. Vehicle, went into a "creep mode" immediately following one of the instances, but the computer reset itself after several minutes. The vehicle was not repaired. The vehicle was taken to an authorized dealer, who stated that the transmission would need to be replaced. After months of complaining and noticing all of the other vehicles in my class have the same issues, it baffled me why FORD would not replace this troubling part. Report a safety problem Find recalls by VIN. 2005 Ford Five Hundred Recalls | CarComplaints.com I read on the internet about the complaints and the first thing I did was to replace the throttle body and the throttle body position sensor - that didn't help. I took my car to a mechanic because the check engine light was on. Also note: this only applies to vehicles with single or dual automatic climate control. Worried about potential repair costs? I just bought a pedal sensor in the hope of improving my issue . Automatic Transmissions for 2005 Ford Five Hundred 4. 2006 Ford Five Hundred Review & Ratings | Edmunds Page 56 Vertical aim adjustment 1. Recall information from this VIN lookup tool is provided by the manufacturer conducting the recall. Began to hear noise in front within 10 miles front transaxle went out. Transmission fluid leak at bottom of tranny pan. The process usually takes a few hours, and you may need to leave your car overnight. They took it apart and put it back together and said all is well. There seems to be a problem serving the request at this time. The recall is for a software issue that could result in the CVT going into "limp" mode, which limits the vehicle to a maximum speed of 5 miles per hour. In August 2010, I had the continuously variable transmission replaced at ~98,000 miles. The contact stated that the transmission was replaced and within a couple of days she drove the vehicle again and it stalled. Post by jfc Tue . The transmission was replaced successfully. Inside the 05 Ford 500 CVT transmission - YouTube Normally, the fan speed changes only to maintain a selected temperature, but when the fan speed changes frequently and needlessly, there is an issue with the fan speed control unit. Sign up for alerts and we'll. 55800 mi C $350 - Additional information on checking transmission fluid levels. 2005 Ford Five Hundred Problems, Defects & Complaints Where Is the Transmission Control Module Located? - 2CarPros While driving various speeds, it was difficult to shift gears. and I was traveling down the road and came to a red light and when I slowed down to check for traffic, my wrench check-engine light came on. Given that I have either purchased or leased 6 vehicles from this dealership in the past 17 years, I am going to ask them to advocate a replacement with Ford on my behalf. Steering is whining on both left and rights terns low and high speeds The vehicle was towed to the dealer where they diagnosed that the throttle bottle needed to be replaced. When I looked at the dipstick, the fluid was red/pink and clearish, not burnt or anything like that. I'm guessing the CVT has none and I watched a video for the 6 speed automatic trans. .. New comments cannot be posted and votes cannot be cast, Press J to jump to the feed. I hear ya, and except for the fact that I lost my sis and she left the car to me, I'd be doing exactly that. . I need to change the ECT sensor, don't know where is it in the Ford 500 2005 can you please help me. Engine not reving or remaining at idle when you press throttle would be something else. Normally, the fan speed changes only to maintain a selected temperature, but when the fan speed changes frequently and needlessly, there is an issue with the fan speed control unit. Ford Five Hundred - Consumer Reports - Product Reviews and Ratings Ford / five hundred / 2005; The 2006 ford five hundred has air conditioner and heating problems. 2005 ford five hundred. Minor repairs are typically those that can be fixed quickly and without too much hassle. Ford Five Hundred/Mercury Montego: Noises - Car Forums Post by jfc Mon Jun 06, 2011 12:30 am. If the key is not.. 3of my outside door handles were yanked off Nd I have been using a string I hooked to the latch to open the door how do I fix them I been looking all over the internet and cant seem to find a solut.. I gather this to mean that if they have to pull the trans then it's time for a full rebuild. However from that point on, the transmission worked well until I sold the Aerostar 100,000 miles later. With the option of a folding front passenger seat, a Five Hundred was able to carry objects up to ten feet long inside the vehicle. FORD 500 w/30,000 miles and per dealer broken motor mount and not covered under warranty? can cause the Images (Click to enlarge) SPONSORED LINKS. I asked the service manager why they just didnt hone the cylinder wall and he said that Ford wouldnt allow this. refused repair. Local repair shop scanned vehicles repair codes, determined it to be a transmission failure. Powertrain and Chassis Repair Frequencies. Tuesday,.. 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 96, 000 MILES, 2005 FORD FIVE HUNDRED, 4 CYL, 2WD, AUTOMATIC, 100, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 120, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 60, 000 MILES, 2005 FORD FIVE HUNDRED, 3.0L, 6 CYL, 2WD, AUTOMATIC, 125, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, AWD, AUTOMATIC, 56, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, AWD, AUTOMATIC, 94, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 26, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 2WD, AUTOMATIC, 85, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 2WD, AUTOMATIC, 63, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 43, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 2WD, AUTOMATIC, 175, 000 MILES, 2005 FORD FIVE HUNDRED, 3.0L, 6 CYL, 2WD, AUTOMATIC, 156, 700 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, AUTOMATIC, 155, 000 MILES, 2005 Ford Five-Hundred Harsh or Delayed Shifting of Automatic Transmission, 2005 Ford Five-Hundred Wrench Light, Service Engine Soon Light, Possible Poor Throttle Response, 2005 Ford Five-Hundred Rear Brakes Wear Out Abnormally Fast, 2005 Ford Five-Hundred Slipping and Hard Shifts from Automatic Transmission, 2005 Ford Five-Hundred Transmission Shifter is Hard To Move, 2005 Ford Five-Hundred Coolant Leakage from Heater Core, Possible Leakage onto Passenger Side Foot Well, 2005 Ford Five-Hundred Blower Motor Only Works on High, 2005 Ford Five-Hundred A/C Fan Speed Changing Constantly, Ford Five Hundred 2005 Ford 500 Door Handles, Ford Five Hundred Where The ECT Is Locater In Ford 500 3.0 2005, Ford Five Hundred 2005 Ford 500 F2 Fuse Blows Instantly, Ford Five Hundred Ford 500 2005 Water Pump, Ford Five Hundred 2005 Ford 500 Power Steering Groan Noise, Ford Five Hundred Steering Column Makes Rubbing Noise When Hot, Ford Five Hundred 2005 Ford 500 Temp Is Irradic At Best.
